Ford Aerostar Recalls

Certain vehicles, from Ontario to Newfoundland, could experience a corrosion related failure of the spare tire winch cable. If the cable breaks while the vehicle is being driven, t

On certain vehicles equipped with 3.0 llitre engines, the accelerator cable may have been kinked during installation. If the cable is kinked, the core wires could eventually fray,

On certain all wheel drive vehicles, extended operation at speeds of over 130 KPH may result in structural failure of the transmission/transfer case assembly. This could result in

On certain vehicles, a short circuit could occur at the A2 accessory terminal in the ignition switch of these vehicles when the switch is in the "on" position causing overheating a

On certain vehicles, a short circuit could cause heat damage, including melting or charring of the wire harness for the fuel pump and sender assembly and associated wire harnesses.

On certain Aerostar AWD vehicles, extended operation at speeds of over 130 kph may result in structural failure of the transmission/transfer case assembly. This could result in flu

THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. VEHICLES MAY HAVE BEEN BUILT WITH INCORRECT MASS AIRFLOW SENSORS INSTALLED IN THE EMISSIONS CONTROL SYSTEM.

THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S 206 - DOOR LATCHES, HINGES AND LOCKS. THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1000 POU

A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE

THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 120 - TIRE SELECTION AND RIMS FOR VEHICLES OTHER THAN PASSENGER CARS. CERTIFICATION LABELS SPECIFY A "70" SERIES REAR TIRE RATHER THAN

THE SPARE TIRE SUPPLIED WITH THE VEHICLE MAY CONTACT THE BRAKE LINES ON THE REAR AXLE IF IT IS MOUNTED IN THE UNDERBODY SPARE TIRE CARRIER. OVER TIME, SUCH CONTACT COULD RESULT IN

NOTE: ALSO INCLUDES SOME MEDIUM AND HEAVY TRUCKS. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. DAYTIME RUNNING LIGHT MODULE MAY MALFUNCTION WHICH CAN RESULT IN DAY

NOTE: TEMPO/TOPAZ WITH 2.3 LITRE ENGINE AND AEROSTAR WITH 3.0 LITRE ENGINE. THESE VEHICLES SO NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. DEFECTIVE THROTTLE POSITION SENSO

THE PARK MECHANISM OF THE A4LD AUTOMATIC TRANSMISSION MAY NOT ENGAGE WHEN THE SELECTOR LEVER IS PLACED IN THE "PARK" POSITION. IF PARKED ON AN INCLINE, THE VEHICLE MAY ROLL AS IF I

THE REAR LIFTGATE GAS CYLINDER-TO-BODY ATTACHMENT BALL STUDS MAY FRACTURE. IF A BALL STUD FRACTURES, THE LIFTGATE WILL NOT REMAIN IN THE OPEN POSITION. BODILY INJURY COULD RESULT I

NOTE: VEHICLES EQUIPPED WITH QUAD CAPTAIN'S CHAIRS. THE LATCH RETAINING THE SECOND ROW RIGHT HAND SEAT ASSEMBLY MAY RELEASE UNDER SEVERE FRONTAL IMPACT CONDITIONS. THIS WOULD ALLOW

THESE VEHICLES MAY HAVE AN INADEQUATE SEAL BETWEEN THE FUEL TANK FILLER PIPE OPENING AND THE FUEL TANK FILLER PIPE GROMMET. THIS COULD RESULT IN FUEL SEEPAGE FROM THE JOINT WHEN TH

AN INABILITY TO MAINTAIN PRESSURE IN THE SECONDARY SYSTEM OF THE MASTER CYLINDER AT TEMPERATURES BELOW 4 DEGREES CELSIUS RESULTS IN INCREASED BRAKE PEDAL TRAVEL AND A REDUCTION OF

THE WEBBING OF THE FRONT PASSENGER-SIDE SEAT BELTS MAY BECOME ABRADED OR CUT DUE TO CONTACT WITH THE OUTBOARD SEAT BACK PIVOT HINGE. CORRECTION: A PLASTIC COVER WILL BE INSTALLED O

On certain vehicles, wiring for the power lumbar seat system was routed directly beneath the seat cushion springs on the side of the cushion. This could result in the insulation be

THE AFFECTED VEHICLES ARE EQUIPPED WITH THE OPTIONAL TRAILER TOW PACKAGE. THE TAILLIGHT RELAY ASSEMBLY MAY HAVE WIRES THAT ARE OF A SMALLER GAUGE THAN THE FUSE LINK WHICH IS PROTEC

ON VEHICLES WITH EFI OR CFI, THE SPRING-LOCK FUEL LINE COUPLING USED TO CONNECT THE FUEL SUPPLY AND RETURN LINES TO THE EFI FUEL RAILS OR TO THE CFI THROTTLE BODIES AS WELL AS OTHE

REAR SUSPENSION ATTACHMENTS MAY BE INADEQUATELY WELDED AND COULD SEPARATE FROM THE UNDERBODY DURING VEHICLE USE. THIS COULD CAUSE LIMITED MOVEMENT OF THE AXLE DURING ACCELERATION O