Ford F Series — Emissions
High risk
Sep 15, 1999
Model years: 1996, 1997, 1998, 1999
Certain CNG vehicles do not comply with the requirements of CMVSS 1105 - Evaporative Emissions. The natural gas fuel fill valve may leak due to flaking of the nickel plating inside
Also affects: Ford Crown Victoria, Ford Econoline
Ford F Series — Engine
High risk
Aug 20, 1997
Model years: 1992, 1993, 1994, 1995
On certain B600, F600 and P800 vehicles, engine resonance can cause elevated stress conditions and a fatigue failure of the accelerator return springs. A failed return spring could
Also affects: Ford B Series, Ford P Series
Ford F Series — Electrical
High risk
May 10, 1996
Model years: 1994, 1995
NOTE: SUPER CAB PICKUPS WITH OPTIONAL 40/20/40 POWER FRONT DRIVER SEAT. THE FRONT SEAT CUSHION SUPPORT WIRES COULD CONTACT AND DAMAGE THE INSULATION ON THE WIRE HARNESS FOR THE POW
Ford F Series — Electrical
High risk
Nov 29, 1995
Model years: 1988, 1989, 1990, 1991
A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE
Also affects: Ford Aerostar, Ford Bronco, Ford Bronco Ii, Ford Crown Victoria, Ford Escort
Ford F Series — Engine
High risk
Oct 20, 1995
Model years: 1992, 1993, 1994
On certain B700, F700, F800, FT900, L8000, LA8000, LN7000, LN8000, LNT8000, LS8000, LT8000 and LTS8000, the Hand throttle cable may wear the brass swivel block on the governor leve
Also affects: Ford B Series, Ford L Series
Ford F Series — Engine
High risk
Jun 9, 1995
Model years: 1993
On certain B600 and F600 vehicles, a tolerance stack-up condition on the accelerator lever and the automatic transmission modulator lever may result in interference between the two
Also affects: Ford B Series
Ford F Series — Electrical
High risk
Jun 9, 1995
Model years: 1994, 1995
On certain B600, B700, F600, F700, F800, FT900, LA9000, LL9000, LTA9000 and LTL9000 vehicles, a connector where the wiring for lamps mounted on the tilt hood attaches to the vehicl
Also affects: Ford B Series, Ford L Series
Ford F Series — Emissions
High risk
Feb 27, 1995
Model years: 1995
THESE VEHICLES MAY HAVE BEEN BUILT WITH IGNITION CONTROL (IC) MODULES WHICH MAY FAIL AND CAUSE A NO START CONDITION. A FAULTY IC MODULE WOULD NOT BE IN COMPLIANCE WITH C.M.V.S.S. 1
Also affects: Ford E Series
Ford F Series — Brakes
High risk
Oct 17, 1994
Model years: 1992, 1993, 1994
NOTE: THIS RECALL AFFECTS VEHICLES WITH MANUAL TRANSMISSION. THE PARKING BRAKE CONTROL SELF-ADJUST PAWL MAY SKIP OVER ONE OR MORE TEETH IN THE SELF-ADJUST RATCHET DURING PARKING BR
Also affects: Ford Bronco, Ford Explorer, Ford Ranger
Ford F Series — Engine
High risk
Jun 8, 1994
Model years: 1994
VEHICLES EQUIPPED WITH THE DIRECT INJECTION TURBO DIESEL ENGINE MAY EXPERIENCE A CONDITION WHEREBY THE VEHICLE, WHEN IN CRUISE CONTROL MODE, WOULD CONTINUE TO ACCELERATE FOR A PERI
Also affects: Ford Super Duty
Ford F Series — Structure
High risk
Jan 24, 1994
Model years: 1993, 1994
THE U-CLIPS USED IN ATTACHING THE FRONT BUMPER INNER ARM TO THE BUMPER FACE BAR MAY FRACTURE. IF NOT REPLACED, THE FRONT BUMPER MAY LOOSEN AND SEPARATE WHICH COULD CAUSE THE VEHICL
Also affects: Ford Bronco, Ford Super Duty
Ford F Series — Seats And Restraints
High risk
Nov 26, 1993
Model years: 1994
NOTE: VEHICLES UNDER 8500 LB. GVWR. THESE VEHICLES MAY HAVE BEEN BUILT WITH NON-FUNCTIONAL AIR BAG DIAGNOSTIC MODULES. IF SO EQUIPPED, THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM AND
Ford F Series — Engine
High risk
Nov 24, 1993
Model years: 1992, 1993
NOTE: INCLUDES TRUCKS, TRUCK CHASSIS AND BUS CHASSIS. MEDIUM AND HEAVY DUTY VEHICLES EQUIPPED WITH CUMMINS 5.9 LITRE AND 8.3 LITRE DIESEL ENGINES WITH IN-LINE FUEL INJECTION PUMPS
Also affects: Ford B Series, Ford Cf Series, Ford L Series
Ford F Series — Fuel System
High risk
Jul 20, 1993
Model years: 1990, 1991, 1992, 1993
VEHICLES WITH GASOLINE ENGINES AND DUAL FUEL TANKS MAY EXPERIENCE THE TRANSFER OF FUEL FROM ONE TANK TO THE OTHER THROUGH A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY
Ford F Series — Suspension
High risk
Dec 22, 1992
Model years: 1993
NOTE: INCOMPLETE CHASSIS-CABS. ONE OR MORE OF THE SIX CLAMPS THAT HOLD THE TIRE AND RIM ASSEMBLY TO THE CAST SPOKES OF THE FRONT WHEEL MAY HAVE BEEN OF AN INCORRECT SIZE. INSTALLAT
Also affects: Ford B Series, Ford L Series
Ford F Series — Lights And Instruments
High risk
Jun 30, 1992
Model years: 1990, 1991
NOTE: ALSO INCLUDES SOME MEDIUM AND HEAVY TRUCKS. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. DAYTIME RUNNING LIGHT MODULE MAY MALFUNCTION WHICH CAN RESULT IN DAY
Also affects: Ford Aerostar, Ford Bronco, Ford Bronco Ii, Ford Econoline, Ford Escort
Ford F Series — Structure
High risk
Feb 5, 1992
Model years: 1992
IF VEHICLES ARE OPERATED IN BELOW FREEZING TEMPERATURES AND IF WATER ENTERS THE DOOR LATCH RELEASE CABLE, THE WATER MAY FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION. THIS CO
Also affects: Ford Bronco, Ford Ranger
Ford F Series — Fuel System
High risk
Dec 9, 1991
Model years: 1989
ON VEHICLES WITH DUAL FUEL TANKS, THE DUAL FUNCTION FUEL RESERVOIR (DFR) MAY MALFUNCTION ALLOWING SUPPLY FUEL TO BE DRAWN FROM ONE TANK AND A PORTION OF THE UNUSED FUEL TO BE RETUR
Also affects: Ford Econoline, Ford Super Duty
Ford F Series — Brakes
High risk
Dec 6, 1990
Model years: 1989, 1990, 1991
CRACKS MAY DEVELOP IN THE MOUNTING SURFACE AREA OF AEROQUIP MAXI II 30/36 SPRING PARKING BRAKE CHAMBERS POSSIBLY LEADING TO FRACTURE OF THE CHAMBER HOUSING IN THE AREA OF THE STUDS
Also affects: Ford Cl Series, Ford C Series, Ford L Series
Ford F Series — Brakes
High risk
Jun 11, 1990
Model years: 1990
VEHICLES WERE BUILT WITH A 2.00 INCH MASTER CYLINDER IN PLACE OF THE 1.75 INCH MASTER CYLINDER NORMALLY UTILIZED. THE LARGER MASTER CYLINDER WILL PROVIDE LESS LINE PRESSURE TO THE
Also affects: Ford B Series
Ford F Series — Powertrain
High risk
May 30, 1990
Model years: 1989, 1990
A SNAP RING WHICH LOCATES THE PARK GEAR ON THE OUTPUT SHAFT OF THE TRANSMISSION MAY FRACTURE AND ALLOW THE PARK GEAR TO SLIDE REARWARD. THIS WOULD MAKE IT IMPOSSIBLE TO ENGAGE THE
Also affects: Ford Econoline
Ford F Series — Fuel System
High risk
Jan 2, 1990
Model years: 1986, 1987, 1988, 1989
NOTE: THIS RECALL SUPERSEDES RECALL 88164. VEHICLES LOCATED IN THE YUKON, NOTHWEST TERRITORIES, ALBERTA, EASTERN BRITISH COLUMBIA, N.W. ONTARIO, MANITOBA AND SASKATCHEWAN. A SHORT,
Also affects: Ford Bronco
Ford F Series — Fuel System
High risk
Dec 2, 1988
Model years: 1986, 1987, 1988, 1989
A SHORT, U-SHAPED NYLON FUEL TUBE (JUMPER TUBE) LOCATED ON THE LEFT-HAND FRAME RAIL CONNECTING THE FUEL PUMP TO THE FUEL FILTER COULD DEVELOP PIN HOLES IN THE TUBING WALL. IF THIS
Also affects: Ford Bronco
Ford F Series — Fuel System
High risk
Sep 9, 1987
Model years: 1985, 1986, 1987
ON VEHICLES WITH EFI OR CFI, THE SPRING-LOCK FUEL LINE COUPLING USED TO CONNECT THE FUEL SUPPLY AND RETURN LINES TO THE EFI FUEL RAILS OR TO THE CFI THROTTLE BODIES AS WELL AS OTHE
Also affects: Ford Bronco, Mercury Cougar, Mercury Sable, Ford Taurus, Ford Aerostar
Ford F Series — Engine
High risk
May 1, 1987
Model years: 1987
VEHICLES EQUIPPED WITH 6.6L AND 7.8L ENGINES. DIESEL ENGINE GOVERNOR ASSEMBLIES MAY HAVE LEVER RETAINING RINGS INSTALLED IN A REVERSED POSITION. AS A RESULT, ONE OR MORE OF THREE R
Also affects: Ford L Series, Ford B Series
Ford F Series — Brakes
High risk
Dec 24, 1985
Model years: 1984, 1985
THE HYDRAULIC PARKING BRAKE CONTROL VALVE MAY INADVERTENTLY ACTIVATE DUE TO MOMENTARY PRESSURE DISRUPTION IN THE HYDRAULIC PARKING BRAKE SYSTEM, RESULTING IN THE APPLICATION OF THE
Also affects: Ford L Series, Ford 8000, Ford B Series, Ford C Series, Ford 6000
Ford F Series — Brakes
High risk
Oct 29, 1984
Model years: 1984
On certain vehicles, the hydraulic brake booster supply hoses are located too near the exhaust manifold heat shrouds and may be susceptible to chaging and/ or heat damage. This cou
Also affects: Ford 700, Ford 800, Ford B Series
Ford F Series — Not Entered
High risk
Sep 28, 1984
Model years: 1984
CARBURETOR THROTTLE SHAFTS MAY BE SUSCEPTIBLE TO DIRT CONTAMINATION AND WEAR OF THE BEARING COATINGS. THIS COULD CAUSE THE SECONDARY THROTTLE PLATES TO REMAIN PARTIALLY OPEN AFTER
Also affects: Ford Bronco, Ford Club Wagon, Ford Econoline, Ford Mustang, Mercury Capri
Ford F Series — Brakes
High risk
Mar 17, 1983
Model years: 1982
Certain vehicles may have been built with left rear brake assemblies that were incorrectly produced with one or both automatic brake adjusters what were intended for right rear bra
Also affects: Ford B Series, Ford C Series, Ford L Series
Ford F Series — Not Entered
High risk
Mar 3, 1983
Model years: 1983
VEHICLES EQUIPPED WITH AUTOMATIC OVER DRIVE TRANSMISSIONS. THE PARKING PAWL ACTUATING CAM RETAINER PIN ON THE AUTOMATIC TRANSMISSION ACTUATING ROD ASSEMBLY MAY HAVE BEEN INCORRECTL
Also affects: Ford Club Wagon, Ford Crown Victoria, Ford Econoline, Lincoln Continental, Lincoln Mark Iv
Ford F Series — Electrical
High risk
Feb 18, 1983
Model years: 1983
On certain B600, B700, B7000, F600, F700, F800, F8000, FT600, FT700, FT800 and FT8000 vehicles, wires from the main wiring harness to the foot operated headlamp dimmer switches may
Also affects: Ford B Series, Ford Ft Series
Ford F Series — Engine
High risk
Dec 8, 1982
Model years: 1981, 1982, 1983
On certain B600, B700, B800, F600, F700 and F800 vehicles, an incorrect end clamp on the hand throttle actuating cable may interfere with the outboard accelerator return spring. If
Also affects: Ford B Series
Ford F Series — Not Entered
High risk
Apr 26, 1982
Model years: 1975, 1976, 1977, 1978, 1979, 1980, 1981
VEHICLES DO NOT COMPLY WITH CMVSS 124 - ACCELERATOR CONTROL SYSTEMS.
Also affects: Ford C Series, Ford L Series
Ford F Series — Brakes
High risk
Oct 16, 1981
Model years: 1980, 1981
On certain B600, B700, F600, F700 and F800 vehicles, the brake master cylinder to chassis tube and hose assemblies are located in a position that may be susceptibel to chafing duri
Also affects: Ford B Series
Ford F Series — Brakes
High risk
Jul 16, 1981
Model years: 1981
On ceratin B600, B700, B800, F600, F700 and F800 vehicles, the left handfront brake tube retaining clip missing. Absence of clip may allow tube to chafe against shock absorber caus
Also affects: Ford B Series
Ford F Series — Electrical
High risk
Jun 12, 1981
Model years: 1980, 1981
On ceratin B600, B700, F600, F700 and F800 vehicles, primary electrical circuit connector could deteriorate and cause loss of engine operation resulting inloss of power steering as
Also affects: Ford B Series
Ford F Series — Not Entered
High risk
May 11, 1979
Model years: 1979
SOME BRAKE PUSHROD TO BRAKE PEDAL RETAINING PINS WERE INCORRECTLY HEAT TREATED AND MAY NOT MAINTAIN THE REQUIRED SET WHEN INSTALLED. THE RETAINING PIN MAY FALL OUT ALLOWING A POSSI
Also affects: Ford Bronco, Ford Econoline, Ford Fairmont, Ford Granada, Ford Ltd Ii
Ford F Series — Brakes
High risk
Mar 30, 1979
Model years: 1975, 1976, 1977, 1978, 1979
On certain B700, C600, CL9000, F700, LN600 and W9000 vehicles equipped with eaton anti-lock air brake controllers and produced at the kentucky turck plant. A nylon piston within th
Also affects: Ford B Series, Ford C Series, Ford Cl Series, Ford L Series, Ford W Series
Ford F Series — Not Entered
High risk
Nov 23, 1978
Model years: 1979
VEHICLES EQUIPPED WITH C-6 AUTOMATIC TRANSMISSIONS. COME C-6 PARKED WITHOUT THE PARKING BRAKE ENGAGED, THE VEHICLE COULD ROLL FREE CAUSING PROPERTY DAMAGE OR PERSONAL INJURY.
Also affects: Ford Bronco, Ford Club Wagon, Ford Econoline, Lincoln Mark V
Ford F Series — Other
High risk
Oct 18, 1978
Model years: 1971, 1972, 1973, 1974
On certain trucks, the blades of the cross- blade type engine cooling fan may fatigue crack and separate without warning, while the engine is operating. Fan blade separation may da
Also affects: Ford B Series, Ford L Series
Ford F Series — Not Entered
High risk
Sep 15, 1978
Model years: 1979
VEHICLES EQUIPPED WITH C-6 AUTOMATIC TRANSMISSIONS. COME C-6 AUTOMATIC TRANSMISSIONS CONTAIN PARKING PAWL ACTUATING RODS THAT WERE NOT HEAT TREATED AND CAN DEFORM DURING USE. THIS
Also affects: Ford Bronco, Ford Club Wagon, Ford Econoline, Lincoln Mark V
Ford F Series — Other
High risk
Jul 5, 1978
Model years: 1975, 1976, 1977, 1978
On certain trucks, the blades of the engine cooling fan may fatigue crack and separate, without warning, while the engine is operating. Fan blade separation may damage underhood co
Also affects: Ford B Series, Ford L Series
Ford F Series — Not Entered
High risk
Mar 3, 1978
Model years: 1964, 1965, 1966, 1967, 1968, 1970, 1979
VEHICLES EQUIPPED WITH ROCKWELL INTERNATIONAL MALLEABLE IRON FRONT WHEEL HUBS INSTALLED ON 12,L000 LB. CAPACITY FE970 CENTERPOINT STEERING AXLES. THE FRONT WHEEL HUBS MAY EXPERIENC
Also affects: Ford C Series, Ford Ct Series, Ford H Series, Ford Ht Series, Ford Nt Series
Ford F Series — Not Entered
High risk
Feb 14, 1978
Model years: 1978
VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND OPTIONAL TILT STEERING COLUMN. VEHICLES MAY HAVE BEEN BUILT WITH DEFORMED SHIFT SELECTOR LEVER REACTION SPRINGS WHICH CAN REDUCE O
Also affects: Ford Bronco, Ford Club Wagon, Ford Econoline
Ford F Series — Fuel System
High risk
Sep 29, 1977
Model years: 1977
Certain vehicles equipped with 351 and 400 cleveland engines. Certain cleveland engines may experience fuel leakage at the rubber hose connecting the fuel inlet tube to the carbure
Also affects: Ford Ltd Ii, Ford Ranchero, Ford Thunderbird, Mercury Cougar
Ford F Series — Engine
High risk
Sep 29, 1977
Model years: 1977, 1978
Certain vehicles equipped with 460 c.i.d. Engines and 4350-4v carburetors. The secondary throttle lever of the 4350-4v carburetor may experience a "hang-up" condition due to a die
Also affects: Ford Club Wagon, Ford E250, Ford E350, Ford Econoline, Lincoln Mark V
Ford F Series — Not Entered
High risk
Mar 4, 1976
Model years: 1975
SUSPECT VEHICLES MAY HAVE BEEN EQUIPPED WITH FRONT SPRING REAR HANGER BRACKETS ON WHICH THE CHANNEL AND SIDE PLATE COMPONENTS ARE SECURED WITH INSUFFICIENTLY UPSET RIVETS.
Also affects: Ford B Series
RecallTracker